This Service Information bulletin supersedes S.I. B61 03 05 dated November 2005.
designates changes to this revision
SUBJECT
Software Errors Corrected with Progman
MODEL
E90, E91 (3 Series)
SITUATION
Customer may complain of the following:
The following software errors were corrected with the release of Progman 20.00.01 (Target data Status E89x-05-12-510).
1. Unable to Pair or Reconnect a BluetoothÃ’ Handset to a Vehicle. Refer to SI B84 25 05 for further information.
The following software errors were corrected with the release of Progman 20.00.00 (Target data Status E89x-05-12-500).
1. Engine juddering/idle speed surging when it is cold. N52 engine.
2. No customer complaint. The following faults are stored in the JBE (Junction Box Electronics) erroneously. The JBE must be recoded to correct these faults.
* Door Mirror Heating Left – 0xA6DE
* Door Mirror Heating Right – 0xA6DF
3. The fuel gauge reading is incorrect. The fuel gauge indicates higher than the actual amount in the tank.
The following software errors were corrected with the release of CIP 19.02.00 (Target data Status E89x-05-09-530).
No Software corrections included in this version of CIP
The following software errors were corrected with the release of CIP 19.01.00 (Target data Status E89x-05-09-530).
1. CCC (Car Communication Computer) poor AM reception.
2. The audio keeps playing if the vehicle is switched off for up to 3 minutes (until vehicle enters sleep mode). The audio cannot be switched off with the rotary knob. Only vehicles with CCC (Car Communication Computer) are affected.
3. Teleservice: no service calls even though CBS services due. Only vehicles equipped with SA639. Refer to SI B84 19 05.
4. Loss of airflow from defroster vents.
5. After repeated convenience opening and closing using the remote key, only the trunk lid locks and the doors remain unlocked.
6. CCC (Car Communication Computer) equipped vehicles with telephone, call fails when dialed using linked sequence ("p" for pause) stored phone numbers. Refer to SI B84 18 05.
7. Sporadic CCC resets (screen blanks out briefly and CCC restarts).
8. The outside temperature display in RAD2 (BMW Professional radio) does not display any temperatures above 85 deg;F.
9. I-Drive Controller does not function. Central Controller High (ZBE) FC E2C7 "Bus Communication Fault" is stored.
10. The "ELV (Electric Steering Lock) malfunction", check control message may be displayed intermittently when the driver attempts to start the engine. It is not possible to start the engine for 16 minutes unless the vehicle has entered sleep mode.
11. The "Anti-trap protection deactivated" check control message is displayed during one-touch closing of the rear power windows. The window then can only be opened a little when the one-touch opening switch is pressed.
12. While traveling at a slow speed with a constant rain, the automatic wipers do not operate.
13. Rear window roller sunblind does not rewind in low temperatures.
14. After a jump start (battery dead), the adaptive headlights turn briefly to the right without the customer turning the steering wheel, then return to the center position. Vehicles with SA 524 (Adaptive Headlights) produced from 5/31/04 to 8/30/05.
15. Menu button on the iDrive Controller flashes briefly. Vehicles with SA 609 (CCC-Navigation).
16. After the automatic parking function is deactivated (by disengaging reverse gear), the passenger's side mirror does not return to its original position but to the mirror setting stored with the key used.
17. If comfort opening was cancelled (if all the windows are already open) and is then reactivated, intermittently the sunroof does not open until after 4 seconds instead of the normal .5 seconds.
18. Vehicles equipped with SA 322 (Comfort Access) FC "A0AC TAGE3_ antenna defect" may be erroneously stored. After programming the vehicle the system should be checked for proper functionality. If fault code returns perform DIS test module.
19. Luggage compartment opens on its own. E91 only.
The following software errors were corrected with the release of CIP 19.0 (Target data Statuses E89x-05-09-521, E89x-05-06-520).
No Software corrections included in this version of CIP
The following software errors were corrected with the release of CIP 18.00 (Target data Status E89x-05-06-520).
1. The audio keeps playing if the vehicle is switched off for up to 3 minutes (until vehicle enters sleep mode). The audio cannot be switched off with the rotary knob. Only vehicles with CCC (Car Communication Computer) are affected.
The following software errors were corrected with the release of CIP 17.01 (Target data Status E89x-05-06-510).
1. The "Service Engine Soon" light is on. DME (Digital Motor Electronics) FC "29DA Crankshaft Sensor, Segment Adaptation" is stored. Refer to SM B12 214 05.
2. Vehicle may be difficult to start, run rough and/or the "Service Engine Soon" light is illuminated. One or more of the following faults may be stored.
* 2A9A Cam sensor, inlet signal – signal invalid for synchronization
* 2A98 Crankshaft-inlet camshaft, correlation- Value outside reference range
* 2A82 VANOS intake- stiff, jammed mechanically
* 2A9B Cam sensor, exhaust signal – signal invalid for synchronization
* 2A99 Crankshaft- exhaust camshaft, correlation- Value outside reference range
* 2A87 VANOS exhaust- stiff, jammed mechanically
PROCEDURE
For all vehicles, on a customer complaint basis only, refer to the following procedure and warranty information.
1. Update the complete vehicle per SI B09 05 01 (Coding, Individualization, Programming) Procedure B, using Progman 20.00.01 (Target Data Status E89x-05-12-510) or higher.
WARRANTY INFORMATION
Covered under the terms of the BMW New Vehicle Limited Warranty.
Defect Code
Refer to KSD
Labor Operation:
Refer to KSD
http://www.bmwtis.com/tsb/bulletins/...p/B610305g.htm
